Free on-site gate assessment - hinges, posts, and your LiftMaster or Nice gate operator checked before anything is quoted
The assessment is free and the quote is the invoice.
Before
After
Before
After
Before
AfterGhost Controls Keypad & Intercom Repair: The Little Elm Owner’s Guide
Ghost Controls keypad and intercom repair in Little Elm typically runs $145-$295 installed, with most jobs completed in a single visit by a technician who already has the part on the truck. We stock Ghost Controls-compatible keypads, intercom modules, and wiring harnesses for the AXDP, HDP, and TDS series, so the fix usually happens the same day you call. Most homeowners notice the failure the same way: the keypad won’t wake up, the intercom goes quiet, or the gate opens fine from the remote but ignores the keypad entirely. That last one is the tipoff that the board or the keypad itself has failed, not the gate motor.
Which Ghost Controls Models This Applies To
Ghost Controls has kept their keypad and intercom architecture fairly consistent across three main lines: the AXDP series (the most common on Little Elm driveways), the HDP heavy-duty series, and the TDS solar-ready line. The keypad itself is a wireless unit that pairs to the control board through a learn button on the receiver, while the intercom ties in through a wired connection at the board. That distinction matters: a “keypad not working” call is often a pairing issue or a dead battery, while an intercom failure is almost always a board input or wiring fault. Before you pay for a new part, we check the board’s diagnostic LED sequence and test voltage at the intercom terminals. OEM Ghost Controls keypads are well built, but the aftermarket universal keypads we carry match up cleanly and save homeowners about 30% without giving up range or weather sealing. One compatibility note from the field: older Ghost Controls boards with a 3-pin keypad connector won’t accept the newer 4-pin replacement without a small adapter harness. We carry those too, because discovering that after the old part is in the trash is a long afternoon for nobody.
Signs Your Ghost Controls Keypad or Intercom Is Failing
- Keypad backlight stays lit but no digits register. The membrane contacts have worn through, which happens faster in direct Texas sun. The keypad is sealed, so the fix is replacement rather than repair.
- Gate opens with the remote but not the keypad. Your keypad is no longer paired to the board, or the keypad’s transmitter has failed. We see this after power surges or extended blackouts, both common in Little Elm’s storm season.
- Intercom rings but no voice passes either direction. The microphone or speaker element has failed, or the board’s audio circuit is shot. Testing at the board terminals tells us which one before we order anything.
- Keypad works only from two inches away. The keypad battery is dying, or the antenna connection on the board is loose. This one is often a ten-minute fix with a fresh battery and a seated connector.
- Gate activates on its own or right after you enter the code. A stuck button on the keypad or moisture intrusion in the housing can cause phantom triggers. If the keypad case shows hairline cracks, replace it sooner than later, because water getting into the board is a much bigger repair.
Replacement Cost & What’s Included
In Little Elm, you should expect something in this range, agreed before any work starts:
- Keypad replacement (OEM or quality aftermarket): $145-$225 installed, including pairing and testing.
- Intercom module replacement: $185-$295 installed, including wiring verification and board testing.
- Diagnostic call (if no part is needed): Our standard service call applies, and it rolls into the repair price if we do the work.
The spread depends on whether we’re matching an OEM part or an aftermarket equivalent, and whether the control board itself needs attention. The price we quote over the phone is the price on your bill. That’s not a sales line; it’s how Victor Salinas has run the company from day one. Every Ghost Controls repair we complete carries the 90-Day Done Right Promise in writing.
DIY or Call Us?
Keypads and intercoms are low-voltage parts, so the physical danger is minimal compared to a gate spring or a high-tension cable. What gets homeowners into trouble is the pairing and wiring. A Ghost Controls board with a crossed intercom wire or a shorted keypad connector can damage the board itself, and that’s a $300-$500 part instead of a $200 keypad. You can safely check the keypad battery, make sure the keypad face isn’t cracked, and confirm the gate still operates from the remote. Past that, the honest answer is that the diagnostic steps require a multimeter and a comfort level with board-level wiring that most people don’t have and shouldn’t need to develop. If you’d rather the keypad work tomorrow morning than next weekend, call (432) 547-6481 and we’ll get it sorted.
FAQs
In Little Elm’s sun and heat, a Ghost Controls keypad typically lasts 4 to 7 years before the membrane or housing gives out. Units mounted on unshaded south-facing pillars fail sooner; a shaded north-facing mount can run closer to a decade. We recommend replacing the battery annually and checking the case for cracks each spring.
Keypads can’t be repaired because the membrane and transmitter are sealed units, but intercoms sometimes can be if the failure is a loose terminal or a corroded wire end rather than a dead component. We’ll test before we recommend a replacement, and we won’t sell a part you don’t need.
A keypad replacement typically takes 30 to 45 minutes on-site, including pairing and testing. An intercom replacement runs 60 to 90 minutes because we verify wiring and audio in both directions. Most Little Elm jobs are done in one visit.
Our trucks carry Ghost Controls-compatible keypads, intercom modules, harnesses, and adapters for the AXDP, HDP, and TDS lines. We also stock parts for LiftMaster, Mighty Mule, and DoorKing gates, so if a board issue turns out to be something else, we can usually handle it without a return trip. Call (432) 547-6481 for same-day availability in Little Elm.
If your Ghost Controls keypad or intercom has been acting up, or it’s gone quiet entirely, call Ironworks Gate Co. at (432) 547-6481. A live person answers, day or night. We’ll tell you straight what the part costs, when we can be there, and what the fix will take. Free estimates, upfront pricing, and the 90-Day Done Right Promise behind every job. We fix it right the first time, or we come back and fix it right.
Written by Victor Salinas, Owner, Ironworks Gate Co. at Ironworks Gate Co., serving Little Elm and nearby areas.